KGnmarGOwnersManualFOR POTABLE WATER HEATING ONLY NOT SUITABLE FOR SPACE HEATINGNOT FOR USE IN MOBILE HOMESModel No.153.335816 153.335846 153.335863 1
Installation Instructions (cont’d)AWARNINGA gas water heater cannot operate properly without the correct amount of air for combustion. Do not install
Venting Through Roof - Clearances# 0" clearance for 3" (or optional 2") PVC, ABS, or CPVC Schedule 40 piping from combustib
Installation Instructions (cont’d)Combustion Air and Ventilation for Appliances Located in Unconfined SpacesUnconfîned Space is a space whose vo
Installation Instructions (cont’d)Water PipingA WARNINGHOTTER WATER CAN SCALD; Water heaters are intended to produce hot water. Water heated to a temp
Installation Instructions (cont’d)Temperature-Pressure Relief Valve▲WARNINGAt the time of manufacture this water heater was provided with a combinatio
Installation Instructions (cont’d)Filling the Water HeaterA CAUTIONNever use this water heater unless it is completely filled with water. To prevent d
Installation Instructions (cont’d)USE WITHOUT POWER CORD (cont’d)3. A standard V" conduit opening has been made in the water heater junction box
Installation Instructions (cont’d)Venting (cont’d)AWARNINGBe sure vent pipe is properly connected to prevent escape of dangerous flue gases which coul
2. Horizontal runs require a minimum '/" rise per foot.Installation Instructions (cont’d)VENTING SYSTEM EXAMPLE INSTALLATIONS FOR ALL MO
Installation Instructions (cont’d)Venting (contad)CEMENTING PVC, ABS OR CPVC PIPE AND FITTINGSRead and observe ail safety information printed o
Safety PrecautionsAWARNINGImproper installation, adjustment, alteration, service or maintenance can cause death, serious bodily injury, or
Installation Instructions (cont’d)Venting (cont’d)CONNECTING PVC PIPE VENT TO BLOWER1.The manufacturer has supplied a 3" PVC Schedule 40
Venting (cont’d)ALL MODELS3" PVC Schedule 40 vent piping:1. A3" ABS Schedule 40-45° vent cap with wire screen is supplied with t
Installation Instructions (cont’d)Gas PipingA WARNINGMake sure the gas supplied is the same type listed on the model rating plate. The inlet gas press
Installation Instructions (cont’d)Installation ChecklistBEFORE LIGHTING THE PILOT:Check the gas lines for leaks.a. Use a soapy water solution. DO NOT
Operating InstructionsThis water heater is equipped with an electrically operated venting system and a standing pilot. For the burne
Operating InstructionsLightingAWARNINGBEFORE LIGHTING [PROPANE (L.P.) GAS WATER HEATERS]: Propane (LR) gas is heavier than air. Should there be
Operating Instructions (cont’d)Lighting label on the water heater as it appears above the thermostatFOR YOUR SAFETY READ BEFORE LIGHTINGWARNINGIf you
Operating Instructions (contad)Temperature RegulationDue to the nature of the typical gas water heater, the water temperature in certai
Service and AdjustmentTank (Sediment) Cleaning Burner InspectionSedimenr build-up on the tank bottom may cteate varying amounts of noise,
Service and Adjustment (contad)DrainingLP. Gas Control Valve & Burner Assembly Replacement InformationA WARNINGPROPANE (LP.) GAS CONTROL VALVE
Safety PrecautionsAWARNINGAWARNINGA gas water heater cannot operate properly without the correct amount of air for combustion. Do not install in a con
Service and Adjustment (contad)Drain Valve Washer ReplacementNOTE: For replacement, use a x "/«" x '/*" thick washeravailable at y
Troubleshooting GuideStart Up ConditionsTHERMAL EXPANSIONWater supply systems may. because of such events as high line pressure, frequent
Troubleshooting Guide (cont’d)CONDENSATIONWhenever the water heater is filled with cold water, a certain amount of condensation will for
Troubleshooting Guide (cont’d)Operational Conditions (cont’d)“AIR” IN HOT WATER FAUCETSAWARNINGHYDROGEN GAS: Hydrogen gas can be produced in a
Troubleshooting Guide (cont’d)Leakage CheckpointsUse this guide to check a “Leaking” water heater. Many suspected “Leakers” are not lea
Troubleshooting Guide (cont’d)AWARNINGA CAUTIONThis troubleshooting guide has been supplied for use by qualified service personnel who have a com
Troubleshooting Guide (cont’d)Diagram for Electrical System Check on pages 37 and 3836
Troubleshooting Guide (cont’d)ELECTRICAL SYSTEM CHECK(Use diagram on page 36)▲CAUTIONLabel all wiring before disconnecting any wiring; to ensu
Troubleshooting Guide (cont*d)continued from facing page(^heck ff? to ground ror llU/lzU volts.-♦-No - Check #8 to ground for 110/120 volts.No -•
Notes39
SafetyAWARNiNGThe water heater with draft hood installed must be properly vented to a chimney which terminates outdoors. Never operate the wat
Parts Order ListPOWER MISER™ 9 POWER VENT GAS WATER HEATERS MODEL NUMBERS:153.335816153.335846153.335863153.335916153.335943153.33596340 Gal.40Gal.Hig
Parts Order List (cont’d)POWER MISER™ 9 POWER VENT GAS WATER HEATERS MODEL NUMBERS:153.335816 40 Gal.153.335846 40 Gal. High Altitude L.P.153.335863
Parts Order LiPOWER MISER!“ 9 POWER VENT GAS WATER HEATERS MODEL NUMBERS:153.335816 40 Gal.153.33584640 Gal. High Altitude L.P.(153.33586340 Gal. L.P.
Parts Order List (cont’d)POWER MISERi^ 9 POWER VENT GAS WATER HEATERS MODEL NUMBERS:153.335816 40 Gal.153.335846 40 Gal. High Altitude L.P.153.3358
WarrantyAbout Your WarrantyTHE PRICE OF YOUR WATER HEATER DOES NOT INCLUDE A FREE CHECKUP SERVICE CALL. On Water Heater Installations
Table of ContentsSafety Precautions...2-4Table of Contents...
Customer ResponsibilitiesThank You for purchasing a Sears water heater. Properly installed and maintained, it should give you years of
Materials and Basic Tools NeededMaterials NeededTo simplify the installation Sears has available the installation parts shown below. You m
Installation InstructionsRemoving the Old Water Heater© Turn “OFF” the gas supply to the water heater.AWARNINGIf the main gas line shutoff serving aii
Installation InstructionsLocating the New Water HeaterYou should carefully choose an indoor location for the new water heater, because the
Comments to this Manuals